The rate of nonunion in the MRI-detected occult scaphoid fracture.

Aims: There is a lack of published evidence relating to the rate of nonunion seen in occult scaphoid fractures, diagnosed only after MRI. This study reports the rate of delayed union and nonunion in a cohort of patients with MRI-detected acute scaphoid fractures. Methods: This multicentre cohort study at eight centres in the UK included all patients with an acute scaphoid fracture diagnosed on MRI having presented acutely following wrist trauma with normal radiographs. Data were gathered retrospectively for a minimum of 12 months at each centre. The primary outcome measures were the rate of acute surgery, delayed union, and nonunion. Results: A total of 1,989 patients underwent acute MRI for a suspected scaphoid fracture during the study period, of which 256 patients (12.9%) were diagnosed with a previously occult scaphoid fracture. Of the patients with scaphoid fractures, six underwent early surgical fixation (2.3%) and there was a total of 16 cases of delayed or nonunion (6.3%) in the remaining 250 patients treated with cast immobilization. Of the nine nonunions (3.5%), seven underwent surgery (2.7%), one opted for non-surgical treatment, and one failed to attend follow-up. Of the seven delayed unions (2.7%), one (0.4%) was treated with surgery at two months, one (0.4%) did not attend further follow-up, and the remaining five fractures (1.9%) healed after further cast immobilization. All fractures treated with surgery had united at follow-up. There was one complication of surgery (prominent screw requiring removal). Conclusion: MRI-detected scaphoid fractures are not universally benign, with delayed or nonunion of scaphoid fractures diagnosed only after MRI seen in over 6% despite appropriate initial immobilization, with most of these patients with nonunion requiring surgery to achieve union. This study adds weight to the evidence base supporting the use of early MRI for these patients.

Symptomatic Coracoid Fracture Nonunion Treated with Arthroscopic Reduction and Suture Anchor Fixation: A Case Report.

CASE: A 15-year-old female rock climber presented with a traumatic coracoid process fracture of her dominant upper extremity that failed extensive nonoperative treatment. She was treated successfully by arthroscopic reduction and suture anchor fixation. CONCLUSION: A novel surgical technique for coracoid fracture that combines arthroscopic reduction with suture anchor fixation can result in expeditious and durable clinical improvement in a young, high-demand athlete.

Comparison of corticocancellous bone graft from the anterolateral metaphysis of the distal radius versus iliac crest for the treatment of unstable scaphoid nonunion with humpback deformity.

BACKGROUND: Corticocancellous bone grafting from the iliac crest is acceptable treatment for unstable scaphoid nonunion with a viable proximal pole. However, harvesting graft from the iliac crest is associated with donor site morbidity and the requirement of general anesthesia. Thus, bone grafting from the anterolateral metaphysis of the distal radius (DR) can be a treatment option. However, no study has compared the clinical effect between the two grafting techniques. METHODS: From 2014 to 2019, patients with unstable scaphoid nonunion with humpback deformity underwent corticocancellous bone grafting from the anterolateral metaphysis of the DR (group DR) or iliac crest (group IC). Humpback deformity was determined by evaluating the scapholunate angle (SLA) ≥ 60°, intrascaphoid angle (ISA) ≥ 45°, and radiolunate angle (RLA) ≥ 15° from preoperative radiographs and computed tomography scans. The SLA, ISA, and RLA served to gauge carpal alignment. The operative time, grip strength, active range of motion (ROM), the Modified Mayo Wrist score (MMWS), and Disabilities of Arm, Shoulder, and Hand (DASH) score were assessed postoperatively. RESULTS: Thirty-eight patients qualified for the study (group DR, 15; group IC, 23). Union rates did not differ by patient subset (group DR, 100%; group IC, 95.7%; P = .827), and grip strength, ROM, MWS, and DASH score were similar between groups at the last follow-up. The operative time (minutes) was significantly shorter in group DR (median, 98; quartiles, 80, 114) than in group IC (median, 125; quartiles, 105, 150, P < .001). The ISA, RLA, and SLA improved postoperatively in both groups (P < 0.001). The degree of restoring carpal alignment, as evaluated by SLA, showed superior correction capability in group DR (median, 25.3% quartiles, 21.1, 35.3, P < 0.05). Donor site complications were not significantly different between the groups. CONCLUSIONS: Corticocancellous bone graft from the anterolateral metaphysis of the DR for unstable scaphoid nonunion is associated with a shorter operation time and comparable results with that from the iliac crest in regard to union, restoration of carpal alignment, and wrist function. LEVEL OF EVIDENCE: Level III.

Subchondral Radial and Ulnar K-Wire Positioning With Cancellous Bone Graft Shortens Union Time in Scaphoid Waist Nonunion.

BACKGROUND: Bone grafting in patients with scaphoid waist nonunion can present several technical challenges. In this study, we aimed to present a modified surgical technique for scaphoid waist nonunion, which consisted of subchondral radial and ulnar K-wires positions with cancellous bone graft, and to compare the clinical outcome of this modified technique with the conventional method. METHODS: We retrospectively reviewed 72 patients with scaphoid waist nonunion who had been surgically treated between January 2011 and December 2020. Of these, 34 patients were treated with the modified method and 38 with the conventional method. Debridement of the nonunion site was performed using a curette, rongeur, and microburr. Two or 3 K-wires were inserted along the cancellous portion of the scaphoid in the conventional method. In the modified method, 2 K-wires were inserted along the ulnar and radial subchondral portion of the scaphoid to increase the space for bone grafting in the cancellous portion of the scaphoid. The autologous cancellous bone grafted in both the methods. Demographic, radiological, and clinical outcomes were reviewed and compared between the groups. RESULTS: There were no significant differences in demographics and characteristics of nonunion between the 2 groups of patients. The modified method group showed significantly shorter union time than the conventional method group (conventional group: 13.0 ± 1.3 weeks, modified group: 11.4 ± 1.1 weeks; P < 0.001). The bony union rate was 97.1% for the modified method and 89.5% for the conventional method. Satisfactory clinical outcomes (excellent and good Mayo wrist scores) were achieved in 27 cases (81.8%) using the modified method and 22 cases (64.7%) using the conventional method. CONCLUSION: Subchondral radial and ulnar K-wire positioning with cancellous bone graft (modified method) can improve the union time with satisfactory clinical outcomes in the treatment of scaphoid waist nonunion.

Effect of concomitant deformity correction on patient outcomes following femoral (OTA type 32) nonunion repair.

INTRODUCTION: The purpose of this study was to determine what effect, if any, concomitant deformity correction has on outcomes following femoral nonunion repair. METHODS: 605 consecutive patients who presented to our center with a long bone nonunion treated by one of 3 surgeons was queried. Sixty-two patients (10 %) with complete follow up were treated for a fracture nonunion following a Type 32 femur fracture (subtrochanteric, femoral shaft or distal third metaphysis) over an 11-year period. Twenty of these patients underwent a deformity correction (DC)-angular, rotational, or a combination of both-as part of their femoral reconstruction. Patient demographics and initial injury information was reviewed and compared. Outcomes including radiographic healing, time to union, postoperative complications, patient reported pain scores, and functional outcome scores using the Short Musculoskeletal Functional Assessment (SMFA) were recorded. Patients with and without deformity correction were analyzed and compared using independent T-tests and Chi-Square tests. RESULTS: Compared to the non-deformity correction (NDC) cohort, the DC cohort demonstrated a worse complication profile. Notably, the DC cohort had longer time to union (11.6 ± 7.3 months vs 7.6 ± 8.5 months, P = 0.042), reported significantly higher VAS pain scores at 1-year post-op (4.2 ± 2.8 vs 2.3 ± 2.6, P = 0.007), experienced more complications (25 % vs 4.8 %, P = 0.019), and had a higher rate of secondary procedures (30 % vs 4.8 %, P = 0.006). The DC patients reported less improvement in functional capability as displayed by a smaller average improvement in initial and final SMFA scores (P = 0.042) There was no difference in ultimate bone healing (P = 0.585), baseline SMFA (P = 0.294), and latest SMFA (P = 0.066). CONCLUSION: Deformity correction, if needed as part of femoral nonunion repair, is associated with an increased time to heal, greater rate of complications and diminished improvement of functionality. Eventual healing and patient reported outcomes were similar whether a deformity correction is necessary or not. LEVEL OF EVIDENCE: III.

Long-term clinical and radiological results after scaphoid non-union treatment: a retrospective study about 60 cases.

PURPOSE: Scaphoid non-union treatment remains nonconsensual and is based on vascularized or non-vascularized bone grafting. This study aimed to evaluate with a long follow-up the functional, clinical, and radiological outcomes, reported complications and reoperations and studied non-union treatment prognostic factors. METHODS: Patients who had undergone bone graft surgery for scaphoid non-union were retrospectively reviewed. The evaluated outcomes were pain, qDASH, PRWE and MWS scores, active range of motion, grip strength, union rate, scapholunate angle, carpal height, and presence of arthrosis. Complications and reinterventions were also reported. RESULTS: This study included 60 scaphoid non-union treatments with a mean follow-up of 7.7 (1.5-20.3) years. Twenty (33.3%) non-unions were located at the proximal pole, including 6 (10%) with preoperative avascular necrosis (AVN). Union occurred in 51 patients (85%). The functional, clinical, and radiological results were good. The complication rate was 21.3% and the reintervention rate was 16.7%. Subgroup union rate analysis found no difference if the non-union is localized in the proximal pole or if there is AVN. CONCLUSION: With a representative sample of the population and a long follow-up, we have found a good union rate, clinical and functional results regardless of the treatment method chosen. Scaphoid non-union treatment is still controversial and more studies are needed to accurate indications of each graft according to the patient and non-union characteristics. LEVEL OF EVIDENCE IV: Retrospective cohort study.

What Is the Likelihood of Union and Frequency of Complications After Parallel Plating and Supplemental Bone Grafting for Resistant Distal Femoral Nonunions?

BACKGROUND: Management of resistant distal femur nonunions is challenging because patients not only have disability from an unhealed fracture, but also often have a shortened femur, stiff knee, deformities, and bone defects to address during revision surgery. Dual plating of the distal femur in such a setting can maintain stability that allows the nonunion to heal while also addressing bone defects and correcting deformities simultaneously. Dual-plating techniques that have been described lack standardization with regard to the size and type of medial-side implants and configuration of the dual-plate construct. QUESTIONS/PURPOSES: (1) What proportion of patients achieve radiologic evidence of union after parallel plating of resistant distal femoral nonunions? (2) What improvements in function are achieved with this approach, as assessed by improvements in femoral length discrepancy, knee flexion, and patient-reported outcome scores? (3) What complications are associated with the technique? METHODS: Between 2017 and 2020, the senior author of this study treated 38 patients with resistant distal femoral nonunions, defined here as nonunions that persisted for more than 12 months since the injury despite a minimum of two previous internal fixation procedures. During the study period, our preferred technique for treating aseptic, resistant distal femoral nonunions was to use dual plates in a parallel configuration augmented with autografts. Of 38 patients, three patients with active signs of infection who underwent resection and reconstruction using bone transport techniques and two patients older than 65 years with deficient distal femur bone stock who underwent endoprosthetic reconstruction were excluded. Of the 33 included patients, 67% (22 of 33) were male. The median age was 40 years (range 20 to 67 years). Nonunion was articular and metaphyseal in 13 patients and metaphyseal only in 20 patients. Our surgical approach was to remove existing implants, perform intraoperative culturing to rule out infection, debride the nonunion, correct the deformity, perform intra-articular and extra-articular lysis of adhesions with quadriceps release, and apply fixation using medial and lateral fixed-angle anatomic locked implants positioned in a parallel configuration. Every attempt to improve length was undertaken, and the defects were filled with autografts. A total of 97% of patients were followed until union occurred (one of 33 was lost to follow-up before union was documented), and 79% (26 of 33) were assessed for functional outcomes at a minimum of 2 years (median 38 months [range 25 to 60 months]) after excluding patients lost to follow-up and those in whom union did not occur after parallel plating. Union was defined as evidence of central trabecular bridging on AP radiographs and posterior cortical bridging on lateral radiographs. These radiologic criteria were defined to overcome difficulties in assessing radiologic healing in patients with lateral and medial plates. With parallel plating, bridging trabecular bone along the posterior cortex on lateral radiographs and the central region on AP radiographs is visualized and can be appreciated and interpreted as evidence of healing in two orthogonal planes. Preoperative and follow-up clinical assessment of knee ROM, the extent of femoral length correction based on calibrated femoral radiographs before and after surgery, and the evaluation of improvement in lower limb function based on the preoperative and follow-up differences in responses to the lower extremity functional scale (LEFS) were studied (the LEFS is scored from 0 to 80, with higher scores representing better function). Complications and secondary surgical procedures to address them were abstracted from a longitudinally maintained trauma database. RESULTS: Sixty-seven percent (22 of 33) of nonunions showed radiologic healing by 24 weeks, and another 24% (eight of 33) healed by 36 weeks. Six percent (two of 33) did not unite, and one patient was lost to follow-up before union was documented. In the 79% (26 of 33) of patients available for final functional outcome assessment, the median femoral shortening had improved from 2.4 cm (range 0 to 4 cm) to 1.1 cm (range 0 to 2.3 cm; p < 0.001), and the median knee ROM had improved from 70° (range 20° to 110°) to 100° (range 50° to 130°; p = 0.002) after surgery. The median LEFS score improved to 63 (range 41 to 78) compared with 22 (range 15 to 33; p < 0.001) before surgery. Serious complications, including major thromboembolic events, iliac graft site infection, knee stiffness (flexion < 60°), and medial plate impingement necessitating removal, were seen in 30% (10 of 33) of patients. Secondary surgical interventions were performed in 24% (eight of 33) of patients to address procedure-related complications. CONCLUSION: Based on our findings, a high likelihood of union and improvements in knee and lower limb function can be expected with parallel plating of resistant distal femur nonunions using anatomic locked plates. However, the increased frequency of complications observed in our study suggests the need for improvements in dual-plating techniques and to explore possible alternative fixation methods through larger multicenter comparative studies. LEVEL OF EVIDENCE: Level IV, therapeutic study.

Scaphoid nonunion: a novel modification of Matti-Russe technique with enhanced recovery and full clinical and radiographic union.

BACKGROUND: A scaphoid fracture is a common injury affecting the wrist joint. A fracture of the carpus scaphoid can heal uneventfully or be complicated by non-union. Scaphoid non-union can result in persistent wrist pain, and with functional difficulties affecting all activities of daily living of the patients, this disability is expected to be significant since most of these patients are young active adults. HYPOTHESIS: Extensive removal of the bone from the scaphoid, with the application of a large amount of cancellous bone graft and fixation with two to three wires, could lead to a high union rate and a good functional outcome. METHODS: Eighteen patients with scaphoid fracture non-union were recruited during their visit to the upper limb clinic at our institute. Demographic data were collected, and data regarding comorbidities, smoking, manual work, and others were recorded. Data regarding the interval between injury and surgery, time to radiographic union, and functional wrist scores were reported as well. RESULTS: A cohort of 18 patients was included. The mean age of patients was 30 years; most of our patients were healthy (83.3%), and more than two-thirds were smokers (72.2%). The mean follow-up time was 18 months (1.5 years), 15 patients (83.3%) achieved radiographic unions by 2-3 months, and the remaining 3 patients (16.7%) achieved radiographic unions by (4-5) months, i.e., all patients achieved successful radiographic unions by 5 months at maximum. The mean Mayo score for our series was 83.6 (± 12.4), with 5 patients (27%) achieved ≥ 95% which indicates a significantly high functioning wrist in our cohort. CONCLUSION: Our modified technique with enhanced stability from using three k-wires can achieve full clinical and radiographic unions and result in enhanced recovery postoperatively with cast immobilization limited to 6 weeks total. LEVEL OF EVIDENCE: IV Case series study.

Ultrasound assessment of humeral shaft nonunion risk: a feasibility and proof of concept study.

PURPOSE: To determine the feasibility and reliability of ultrasound in the assessment of humeral shaft fracture healing and estimate the accuracy of 6wk ultrasound in predicting nonunion. METHODS: Twelve adults with a non-operatively managed humeral shaft fracture were prospectively recruited and underwent ultrasound scanning at 6wks and 12wks post-injury. Seven blinded observers evaluated sonographic callus appearance to determine intra- and inter-observer reliability. Nonunion prediction accuracy was estimated by comparing images for patients that united (n = 10/12) with those that developed a nonunion (n = 2/12). RESULTS: The mean scan duration was 8 min (5-12) and all patients tolerated the procedure. At 6wks and 12wks, sonographic callus (SC) was present in 11 patients (10 united, one nonunion) and sonographic bridging callus (SBC) in seven (all united). Ultrasound had substantial intra- (weighted kappa: 6wk 0.75; 12wk 0.75) and inter-observer reliability (intraclass correlation coefficient: 6wk 0.60; 12wk 0.76). At 6wks, the absence of SC demonstrated sensitivity 50%, specificity 100%, positive predictive value (PPV) 100% and negative predictive value (NPV) 91% in nonunion prediction (overall accuracy 92%). The absence of SBC demonstrated sensitivity 100%, specificity 70%, PPV 40% and NPV 100% in nonunion prediction (overall accuracy 75%). Of three patients at risk of nonunion (Radiographic Union Score for HUmeral fractures < 8), one had SBC on 6wk ultrasound (that subsequently united) and the others had non-bridging/absent SC (both developed nonunion). CONCLUSIONS: Ultrasound assessment of humeral shaft fracture healing was feasible, reliable and may predict nonunion. Ultrasound could be useful in defining nonunion risk among patients with reduced radiographic callus formation.

Magnetic resonance imaging analysis of the distribution of cartilage damage in scaphoid nonunion.

This study aimed to evaluate the distribution and severity of cartilage damage using magnetic resonance imaging in patients with scaphoid nonunion without advanced wrist arthritis. We retrospectively analysed MRI of patients who underwent osteosynthesis for scaphoid nonunion. Cartilage damage was assessed in eight wrist regions using a modified Whole-Organ Magnetic Resonance Imaging Score. The frequencies of regions affected by any cartilage damage (Score ≥2.5) depicted on MRI were analysed. The study included 32 patients (31 men and one woman), with a mean age of 32 years (SD 11). The distal radioscaphoid (29/32), scaphotrapeziotrapezoid (STT) (22/32), proximal radioscaphoid (14/32) and scaphocapitate (11/32) joints were most commonly affected by degenerative cartilage damage. The STT and proximal radioscaphoid joint were especially likely to be involved in early-stage scaphoid nonunion advanced collapse. We recommend that surgeons should investigate the cartilage status of these joints during decision-making for scaphoid nonunion surgery.Level of evidence: III.

Cancellous bone graft from the distal radius and headless screw fixation for unstable scaphoid waist nonunion.

PURPOSE: Cancellous bone harvested from the distal radius has been used in various hand surgeries, but studies on its use in scaphoid waist nonunions are insufficient. We investigated the usefulness of cancellous bone graft from the distal radius and headless screw fixation in unstable scaphoid waist nonunion. METHODS: Thirty-one patients who underwent cancellous bone graft from the distal radius and headless screw fixation for unstable scaphoid waist nonunion with follow-up for at least 1 year were included. Bone union time, the number of patients with bone union at six and 12 weeks, total number of patients with bone union at last follow-up, and bone union on the computed tomography (CT) image at postoperative six weeks were evaluated. Further, pre- and postoperative radiological measurements, such as scaphoid length and height, lateral intra-scaphoid angle, and height-to-length ratio, and functional outcomes were compared. Additionally, inter-observer reliability of radiologic parameters was checked. RESULTS: Bone union was achieved in 29 patients. There were two nonunions (6.5%). Bone union time was 10.7 (range, 6-26) weeks. Eighteen (58%) and 25 patients (80.6%) were diagnosed with bone union on the plain radiographs at six and 12 weeks, respectively. Twenty-two patients (71%) were diagnosed with bone union on CT performed at six weeks. Radiological measurements and functional outcomes improved postoperatively. The scaphoid length showed good inter-observer agreement. CONCLUSIONS: In treating unstable scaphoid waist nonunion, cancellous bone graft from the distal radius and headless screw fixation achieved 93.5% union and improved radiological measurements as well as functional outcomes.

Augmentative lag screws as a treatment for aseptic hypertrophic nonunion after internal fracture fixation.

BACKGROUND: Hypertrophic nonunion after intramedullary (IM) nailing and plating is Uncommon and the treatment remained controversial. The aim of this study was to show the result of a simple augmentative lag screws technique for vital non-unions after internal fixation PATIENTS AND METHODS: We retrospectively reviewed the patients with nonunion after internal fixation between January 2016 to August 2022. Patients with unacceptable shortening or deformity were excluded as well as nonunion septic cases. All the patients were followed up for at least 6 months. RESULTS: Seven patients achieved bony union in a median time of 12 weeks (IRQ 12-16). There was a failure case with persistent non-union and brokerage of the screws. DISCUSSION: Various techniques have been described to treat non-union after intramedullary nailing or plating. The existing nail is frequently removed, and the non-union site is either re-reamed and re-nailed or fixed with a plate or external fixation devices or rechanged by a nail in the case of plates. In our study of non-union, augmentative lag screws were successfully applied to treat eight patients with aseptic nonunion, resulting in the healing of non-union in all cases except one. CONCLUSION: Augmentative lag screws represent a simple technique for the management of aseptic hypertrophic nonunion after internal fixation with a significantly shorter operating time.

Clinical outcomes in patients with scaphoid non-union treated with the vascularized medial femoral condyle technique a case series.

INTRODUCTION: Non-union is a prevalent complication of scaphoid fractures. Late diagnosis is common and has a clinical impact due to functional limitations for the patient. Multiple treatments have been proposed to manage this complication, ranging from conservative (i.e., orthopedic) to surgical treatment. The vascularized medial femoral condyle technique has shown satisfactory clinical and paraclinical results, mainly in presence of avascular necrosis of the proximal pole but data regarding functional outcomes and patient satisfaction is scarce. This case series aims to describe the clinical and patient-reported outcomes in a consecutive series of patients with non-union of the proximal third of the scaphoid treated with vascularized medial femoral condyle technique. METHODS: Case series reporting results for a consecutive - initial cohort of patients who presented with a non united fracture of the proximal pole of the scaphoid, avascular necrosis of the proximal pole was documented by CT od MRI imaging preoperatively in all patients. Measurement instruments include the q-DASH and PRWE questionnaires, radiographic images, goniometry, and assessment of grip strength. RESULTS: Twelve consecutive patients are included and they represent the initial cases for all surgeons involved; bone union was obtained in 10 patients (83%) after a mean follow-up time of 31 months (6-72), successful improvement in the range of motion and grip strength was documented. A high rate of satisfaction expressed by the patient was obtained, with an average score in Q-DASH of 17.3 and 20.1 in PRWE. CONCLUSIONS: The vascularized medial condyle technique in cases of nonunion of scaphoid fracture is a reproducible treatment in clinical terms, both in imaging and functional terms, and in patient satisfaction. The learning curve is flat for a dedicated multi surgeon team.

Postoperative scaphoid alignment, smoking, and avascular necrosis mostly influence union rate after scaphoid reconstruction: Results from a retrospective single center study involving 370 patients.

Current literature does not definitely demonstrate the superiority of any particular scaphoid reconstruction method. The primary goal of this retrospective single center study was to evaluate the influence of reconstruction techniques and other factors on the union rate after reconstruction of scaphoid nonunions. In the study, 370 patients with nonunions classified as stable (Mayo 1) or unstable (Mayo 2) depending on carpal alignment were included. Minimal radiological follow-up was 3 months. Bone healing after scaphoid reconstruction was evaluated using computer tomography scans in 294 and radiograms in 76 patients. Univariate and multivariate logistic regressions were applied in the analysis. Eight statistically significant factors that influenced the union rate were fixation method, type of previous operations, number of all operations, number of reconstructions, smoking, postoperative pathological lateral intrascaphoid angle (LISA>45°), avascular necrosis (AVN), and stability of nonunion. Smoking and postoperative LISA>45° significantly reduced the probability of bone fusion by approximately 4.4 and 9.5 times, respectively. Patients with reduced vascularity in the nonunion site had a 5.2 times lower chance of bone fusion. Our multivariate logistic regression model can explain 32% of failures after scaphoid reconstruction, including postoperative LISA>45°, patients' present record of smoking, and reduced vascularity in the nonunion site. However, bone graft type does not impact the union rate in general; however, in case of AVN, the tendency toward higher union rates was observed for medial femoral condyle free flaps when compared to other types of graft (non-vascularized and pedicled bone grafts considered as one group, p = 0.09).

Mechanical evaluation of revision surgery for femoral shaft nonunion initially treated with intramedullary nailing: Exchange nailing versus augmentation plating.

INTRODUCTION: Exchange nailing (EN) or augmentation plating (AP) has been employed to treat nonunions after intramedullary nailing for femoral shaft fractures. Although instability is a factor in hypertrophic nonunion, mechanical evaluations have been limited because the contribution of the callus to fracture site stability varies with healing. Our previous study illustrated the potential for evaluation using a finite element analysis (FEA) that incorporates callus material properties. This study aimed to mechanically evaluate revision surgery for nonunions using FEA. MATERIALS AND METHODS: A quantitative computed tomography-based FEA was performed on virtual revision models of a patient with suspected nonunion after intramedullary nailing. In addition to the initial nailing model (IN) with an 11-mm diameter (D) and 360-mm length (L), four EN models with D12mm (EN1), D13mm (EN2), D12mm-L400mm (EN3), and D13mm-L400mm (EN4) nails and three AP models with 5- (AP1), 6- (AP2), and 7-hole (AP3) plates were created. As with bone, callus was assigned inhomogeneous material properties derived from density based on an empirical formula. The hip joint reaction force and muscle forces at maximum load during the gait cycle were applied. The volume ratio of the callus at the fracture site with a tensile failure risk of ≥1 (tensile failure ratio) and bone fragment movement were evaluated. RESULTS: The tensile failure ratio was 11.6 % (IN), 10.1 % (EN1), 6.3 % (EN2), 10.9 % (EN3), 6.2 % (EN4), 6.4 % (AP1), 7.2 % (AP2), and 7.7 % (AP3), respectively. The bone fragment movement showed an opening on the lateral side with the initial intramedullary nailing. However, both revision surgeries reduced the opening, leading to compression except in the EN1 model. The proximal bone fragments were internally rotated relative to the distal fragments, and the rotational instability was more suppressed in models with lower tensile failure ratio. CONCLUSIONS: For EN, the increase in diameter, not length, is important to suppress instability. AP reduces instability, comparable to a 2 mm increase in nail diameter, and screw fixation closer to the fracture site reduces instability. This study suggest that AP is mechanically equivalent to EN and could be an option for revision surgery for femoral shaft nonunions.

Augmentative Plating in the Treatment of Femoral Nonunion after Intramedullary Nail Fixation.

Objective: Failure of bone healing after intramedullary nailing (IMN) of a femoral diaphyseal fracture is an uncommon condition, which can cause obvious pain symptoms and seriously affect the daily life of patients. Ununion of femoral fracture requires treatment to promote successful bone union. Augmentative plating (AP) has yielded good results in treating femoral nonunion after IMN. However, there are few large cohort studies and no technical standard for this treatment. To determine (1) the proportion of individuals with femoral nonunion after IMN who achieved radiographic signs of osseous union following the additional treatment of AP and autogenous bone grafting and (2) the factors associated with the failure of this treatment. Methods: Nonunion after IMN fixation is defined as an unhealed fracture with no radiographic signs of osseous union at least six months after IMN treatment. Osseous union as bridging bone on three of four cortices with the absence of a radiolucent line. Between January 2011 and January 2022, 83 individuals diagnosed with femoral nonunion after IMN fixation underwent AP and an autogenous bone graft. Results: Seventy-six of the 83 nonunion individuals attained osseous union by 12 months. Six of 36 (16.7%) subjects with mono-cortical plates had non-union. Conversely, one of 47 subjects (2%) with bi-cortical plates had non-union. There were 18 individuals whose AP had ≤6 cortices. Five of these 18 (38.5%) individuals had non-union. Two of 65 with an AP of >6 cortices had non-union. AP with ≤ 6 cortices was a major risk factor for the likelihood of unsuccessful procedures compared to AP with > 6 cortices. Three individuals experienced incision infection at the bone graft harvest site and were treated with local wound care. Conclusions: A high proportion of individuals with femoral nonunion after IMN fixation were salvaged by AP and an autogenous bone graft. Bi-cortical plate and screw intersection of more than six cortices may increase the treatment effectiveness. Limitations: There were limitations of this study. First, it was a retrospective study over a 10-year period, and the patients were treated by different orthopedic surgeons. Second, lack of functional evaluation is another limitation of the present work. Generalizability: The technique of bi-cortical plate and screw intersection of more than six cortices is not difficult for experienced orthopedic surgeons, and no special surgical tools is required. Closing Statement: Many literature has confirmed the good effect of APP technology in treating femoral nonunion after intramedullary nail fixation, but there are still cases of failure. Our study may enable this technology to achieve better therapeutic effects.

Patient outcome scores between 1,2- and 2,3-intercompartmental supra-retinacular artery (ICSRA) pedicled vascularised bone grafts (PVBGs) in the treatment of proximal pole scaphoid fracture non-union - a questionnaire study.

BACKGROUND: Numerous studies have been published on the use of 1,2-intercompartmental supra-retinacular artery (ICSRA) as a pedicled vascularised bone graft (PVBG) in scaphoid fracture non-union, however, only very few studies have reported their results of 2,3-ICSRA. The aim of this study was to compare the patient-rated outcome scores between these two PVBGs in proximal pole scaphoid fracture non-union. METHODS: Nineteen patients who underwent surgery for scaphoid non-union between 2017 and 2021 at a single institution were recruited retrospectively in this study. All patients were operated by a one senior orthopaedic surgeon. A mailed questionnaire with the modified mayo wrist (MMW) and the patient rated wrist evaluation (PRWE) scores were sent to the patients. RESULTS: All patients were males with a mean age of 22.5 years. There was no statistically significant difference in the PRWE score between the two PVBGs. However, a statistically significant difference was found in the MMW score, with the 1,2-ICSRA PVBG having better scores. CONCLUSION: Despite the 2,3-ICSRA having a longer arc of rotation, longer nutrient arteries, and is technically easier to incorporate in a PVBG, when compared with the 1,2-ICSRA it did not result in better patient-rated outcome scores.

Minimally Invasive Surgery for Trapezoid Nonunion: Case Report and Review of the Literature.

We report a case of trapezoid nonunion diagnosed 3 months post injury. A 25-year-old male patient felt continuous wrist pain after being injured. His radiograph showed non-union with sclerotic change and bone resorption. He was planned for surgery, and this was done using a minimally invasive technique. Via a dorsal approach, we percutaneously drilled to the nonunion site and freshened the fracture ends. Bone plugs were harvested from the iliac crest using a bone marrow biopsy needle and packed into the nonunion site. The fracture was then fixed with a cannulated headless compression screw. This procedure could be performed without injuring the ligaments around the trapezoid. The patient was immobilised for 4 weeks, and bone union was achieved 6 months after surgery. He had full range of finger and wrist motion and no pain at the final follow-up. Level of Evidence: Level V (Therapeutic).

Evaluation of free vascularized medial femoral condyle bone grafts in the treatment of avascular scaphoid waist nonunion.

OBJECTIVES: The aim of this study was to evaluate the medial femoral condyle (MFC) bone graft procedure for scaphoid waist nonunion with avascular necrosis on magnetic resonance imaging or prior surgery failure. PATIENTS AND METHODS: Between June 2015 and December 2018, a total of 17 patients (16 males, 1 female; mean age: 29±8.2 years; range, 16 to 40 years) with scaphoid waist nonunion who were treated with vascularized MFC bone grafting were retrospectively analyzed. Pre- and postoperative carpal indices, grip strengths for both hands, range of motion, Visual Analog Scale (VAS) pain score, Quick Disabilities of the Arm, Shoulder, and Hand (QDASH) score, and Mayo Wrist Score (MWS) were evaluated. RESULTS: After vascularized MFC bone graft surgery, 15 patients healed and returned to work without any limitations. Ten patients of left scaphoid nonunion and seven cases of right scaphoid nonunion were treated; for eight of these patients, the operation was on the dominant side. Eight of these patients were smokers. The mean follow-up was 22.4±5.8 months. The mean hand grip strength was increased from 74.5 to 84% on the contralateral side (p<0.05). The average revised carpal height ratio improved from 1.57 to 1.59 (p<0.05) and the scapholunate angle changed from 56.9° to 51.6° (p<0.05). CONCLUSION: The MFC bone grafting is one of the best surgical procedures for small defects such as scaphoid waist nonunion with high union rates, good functional outcomes, and minimal donor site morbidity.